Best answer: How much does it cost to rebuild an inboard boat engine

A typical engine rebuild is between $2,500 and $4,000 in parts and labor costs. This type of engine repair might include simply replacing bearings and seals, and obviously taking the engine out and re-installing it.

How much does it cost to rebuild a Mercruiser 350?

Simple rebuild will cost you probably $500.00 – $800.00, if you take the short block to them. If you have to go the marina route it will be BIG $$$ Just remember to tell the shop it is a marine engine, OR if it is just the short block have them use brass freeze plugs and reuse the cam if they can.

How much does it cost to rebuild a 4.3 Mercruiser?

About how much would a major overhaul on a 4.3L Mercruiser cost? A major overhaul would run between $3,500.00 – $4,500.00 on average depending on labor rates in your area and usually the warranty given is 60-90 days, if that long.

IT IS INTERESTING:  Who has the most electric car charging stations

Is it cheaper to rebuild an engine?

It’s quite likely that engine rebuilding can save you money compared to engine replacement depending on the engine problem you are faced with and the cost of the parts needed for the repair. Depending on the situation, rebuilding your engine can save you up-to half of what you would of spent on replacing your engine.

How much is a Mercruiser engine?

MERCRUISER PRICE LIST: 2020 Program Model Year

ENGINE PACKAGE PRICES
6.2L 300 Inboard DTS w/ECT 300-hp $13,145
6.2L 350 Inboard DTS 350-hp $13,045
6.2L 350 Inboard DTS w/ECT 350-hp $14,879
8.2 HORIZON DTS w/ECT 375-hp $18,145

How many hours will a MerCruiser engine last?

The average marine gasoline engine runs for 1,500 hours before needing a major overhaul. The average marine diesel engine will run for more than three times that long and log an average 5,000 hours under the same conditions.

How many hours will a 5.0 MerCruiser last?

The “old rule of thumb” for engine life with moderate duty cycle is 1000 to 2000 hours and about half of that for the outdrive.

How many hours will a 4.3 Mercruiser go?

The average life for raw water cooled engines is 1,000-1,500 hours or less depending on how often they are used and how well they have been maintained. Sitting unused is hard on them, it’s better if they are run and flushed often. I would definetly remove the risers and inspect the risers and manifolds.

How much does it cost to rebuild a Mercruiser outdrive?

$495.95 – Lower unit basic repair cost includes the following: Take apart clean, wire brush, sand. Change drive shaft bearing. Install water pump kit.

IT IS INTERESTING:  Is my windshield washer fluid frozen

How many horsepower is a 4.3 liter Mercruiser?

Power steering is standard, providing you complete and effortless control.

HP / kW 220 / 164
Maximum RPM (WOT) 4400-4800
Engine type V-6
Displacement (L) 4.3
Bore and stroke 4.00 x 3.48 / 101 x 88 mm

Do rebuilt engines last long?

A rebuilt engine gets better gas mileage than your old one and will emit fewer pollutants. Rebuilding engines also saves energy related to processing discarded engines and cars. A remanufactured/rebuilt engine, with proper maintenance, is capable of lasting as long as a new car engine.

Can you rebuild your own engine?

All things considered, rebuilding an engine is no small task, however, with the right tools, knowledge, and time, this is a task that is very possible to do on one’s own.

Is it worth rebuilding a high mileage engine?

When searching for an engine to rebuild the mileage typically isn’t a consideration unless of course the engine is blown in which case the engine block may have significant damage. If the high mileage engine is running it’s probably a pretty good candidate for a rebuild.

Is a MerCruiser a Ford engine?

its not a ford.

How much does it cost to rebuild a 5.0 MerCruiser?

for that job. From my research on the web, a 5.7Lt rebuilt replacement should cost under $3000 per engine, plus labor – 5.0Lt around $2200..

How much does an inboard boat engine cost?

Outboard sailboat engines

If you run an inboard, expect to pay somewhere between $1,000 – $1,500. Most sailboats can do with a small 5 – 10 horsepower outboard engine without problems. These engines are easy to maintain and cheap to run.

IT IS INTERESTING:  What to do if your transmission is overheating
Four wheels